V-22 Osprey: A Flying Shame

(4 of 8)

There's also been controversy over a sandstorm test for the craft. The V-22's tendency to generate a dust storm when it lands in desert-like terrain wasn't examined because "an unusually wet spring resulted in a large amount of vegetation that prevented severe brownouts during landing attempts," the Pentagon's top tester noted. But the program continued, albeit with a caution about the aircraft's ability to fly in dusty conditions.

The Engine-Failure Problem

After the 2000 grounding, Osprey pilots were told to fly less aggressively, which critics say is the only reason no V-22 has crashed since. "They keep talking about all the things it can do, but little by little its operations are being more and more restricted," says Philip Coyle, who monitored the V-22's development as the Pentagon's top weapons tester from 1994 to 2001. The V-22 can fly safely "if used like a truck, carrying people from one safe area to another safe area," he says. "But I don't see them using it in combat situations where they will have to do a lot of maneuvering."

The Marines contend that the V-22 is an assault aircraft and that no pilot who finds himself dodging bullets is going to fly it gently. "The airplane is incredibly maneuverable," says Lieut. Colonel Anthony (Buddy) Bianca, a veteran V-22 pilot. But the dirty little secret about an aircraft that combines the best features of an airplane and a helicopter is that it combines their worst features too. The V-22 can't glide as well as an airplane, and it can't hover as well as a helicopter. If a V-22 loses power while flying like an airplane, it should be able to glide to a rough but survivable belly-flop landing. Its huge, 19-ft.-long (5.7 m) rotors are designed to rip into shreds rather than break apart and tear into the fuselage. But all bets are off if a V-22 is flying like a helicopter, heading in or out of a landing zone, and its engines are disabled by enemy fire or mechanical malfunction.

As originally designed, the V-22 was supposed to survive a loss of engine power when flying like a helicopter by autorotating toward the ground, just as maple seeds do in the fall. Autorotation, which turns a normally soft touchdown into an very hard emergency landing, is at least survivable. It became clear, however, that the design of the Osprey, adjusted many times over, simply could not accommodate the maneuver. The Pentagon slowly conceded the point. "The lack of proven autorotative capability is cause for concern in tilt-rotor aircraft," a 1999 report warned. Two years later, a second study cautioned that the V-22's "probability of a successful autorotational landing ... is very low." Unable to rewrite the laws of physics, the Pentagon determined that the ability to perform the safety procedure was no longer a necessary requirement and crossed it off the V-22's must-have list. "An autorotation to a safe landing is no longer a formal requirement," a 2002 Pentagon report said. "The deletion of safe autorotation landing as a ... requirement recognizes the hybrid nature of the tilt-rotor."

1. A Family Suicide Risk in US Asians?
2. Dark Clouds in Florida for GOP
3. Where's Obama's Passion?
4. A US Shocker on the Wrestling Mat
5. Obama on His Veep Thinking
6. Apple: Battery Problem Caused iPod Overheating
7. British Spies: Licensed to Be Gay
8. It's Time to Kick Out Some Olympic Sports
9. Spray-On Condoms: Still a Hard Sell
10. Raising the Stakes at the Olympics